2010 Ford Ka diesel: common problems and MOT failures

What goes wrong more than usual on a 2010 Ford Ka diesel?

Parts flagged at MOT more often on the 2010 Ford Ka diesel than on all cars registered in 2010.

• Shock absorbers3.1× usual
  Ford Ka

  22.6% All 2010 cars

  7.2%

  Failed outright at MOT: 10%, against 2% of all 2010 cars. The rest were advisories or minor defects.

  Rough price £200–£300 (pair, average rear to front) ClickMechanic

  At the viewing: Push down hard on each corner. It should bounce once and settle. Look for oil on the shock absorber body.

• Coil springs1.9× usual
  Ford Ka

  19.6% All 2010 cars

  10.3%

  Failed outright at MOT: 1%, against 4.3% of all 2010 cars. The rest were advisories or minor defects.

  Rough price £175–£400 (pair, one axle) ClickMechanic

  At the viewing: Look behind each wheel for a snapped spring coil, and listen for a clunk or twang when turning the wheel lock to lock with the car stopped.

• Ball joint2.2× usual
  Ford Ka

  13.4% All 2010 cars

  6.2%

  Failed outright at MOT: 6.9%, against 3.3% of all 2010 cars. The rest were advisories or minor defects.

  Rough price £60–£150 (one joint) ClickMechanic

  At the viewing: Listen for knocking over bumps and check the rubber boots behind the wheels aren't split.

• Handbrake performance5.3× usual
  Ford Ka

  5.3% All 2010 cars

  1%

  Failed outright at MOT: 5.3%, against 1% of all 2010 cars. The rest were advisories or minor defects.

  Rough price £80–£300 our estimate

  At the viewing: Pull the handbrake on a slope. It should hold the car within a few clicks.

Common 2010 Ford Ka diesel MOT failures and advisories

The share of 2010 Ford Ka diesel MOT tests where testers flagged each area, as a fail or an advisory. Rough prices are typical independent-garage costs.

• Suspension
  60% of testsRough price £120–£400

  At the viewing: Listen for knocks over speed bumps, and look behind each front wheel for a snapped coil spring.

• Tyres
  39% of testsRough price £70–£150

  At the viewing: Check the tread on all four tyres, including the inside edges, and look for cracks or bulges.

• Brakes
  35% of testsRough price £150–£350

  At the viewing: Look for a lip on the disc edges and feel for judder or pulling when braking firmly from about 40mph.

• Lights and electrics
  33% of testsRough price £10–£80

  At the viewing: Ask a friend to check every light, including brake lights and indicators, while you operate them.

• Oil and fluid leaks
  16% of testsRough price £80–£600

  At the viewing: Look under the engine and on the ground where the car is usually parked for fresh oil or fluid.

• Wipers, windscreen and mirrors
  11% of testsRough price £15–£250

  At the viewing: Check for chips in the driver's view, and test the wipers and washers.

Known faults on the 2010 Ford Ka diesel

Reported by owners, mechanics and buying guides for this model and age. Check which engine the car has, as some apply to one engine only.

• Worn clutch and gearbox from town driving

  All engines

  A life of town driving wears the clutch, and notchy gear changes can mean an abused gearbox.

  At the viewing: Accelerate in a high gear to check the clutch doesn't slip, and try every gear.

  If it needs doing: Clutch replacement, about £250–£600. ClickMechanic

  Source: What Car?: used Ford Ka 2008-2016 advice

• Blocked DPF (1.3 diesel)

  1.3 diesel

  Short trips can stop the diesel's particulate filter cleaning itself. A rising oil level can mean fuel getting into the oil.

  At the viewing: Ask how the car's been used and check the oil isn't above the top mark.

  If it needs doing: DPF clean or regeneration, about £160–£500. ClickMechanic

  Source: What Car?: used Ford Ka 2008-2016 advice

• Poor accident repairs and rust

  All engines

  Scraped bumpers are common, and cheap accident repairs can rust.

  At the viewing: Look along the panels for mismatched paint, uneven gaps and bubbling.

  Source: What Car?: used Ford Ka 2008-2016 advice

Questions to ask the seller before buying a 2010 Ford Ka diesel

Ask before you travel to see it. A seller who knows the car will have answers, and receipts.

1. Has the clutch been replaced?
2. Has the DPF ever been cleaned?
3. Has the car had any bodywork?
4. Any recent work on the shock absorbers? (Flagged at MOT 3.1× as often on the 2010 Ford Ka diesel as on other cars the same age.)
5. Any recent work on the coil springs? (Flagged at MOT 1.9× as often on the 2010 Ford Ka diesel as on other cars the same age.)
6. Any recent work on the ball joint? (Flagged at MOT 2.2× as often on the 2010 Ford Ka diesel as on other cars the same age.)